series plr dc-dc converters wide input range/up to 3.33:1 isolated regulated up to 5 watt dc-dc converters fully regulated all units shielded this series of low profile 0.300", high efficiency, wide input range, encapsulated regulators come in 85 different models . these units featue a 500 volt dc input to output isolation in b oth single and dual output models. the plr series will operate fro m -25o c to +70o c with no heat sink or electrical derating. these u nits are excellent for applications where input voltage varies dramaticall y, yet a high efficiency and output voltage regulation must be ma intained. typical characteristics: test conditions: 25o c ambient. operating temperature: -25o c to +70o c ambient. output voltage tolerance: 1% at typical input voltage output voltage temperature coefficient: 0.02%/oc storage temperature: -55o c to +125o c short circuit protection: temporary operating frequency: 40 khz, typical options available features voltage regulation over input range of 0.300" height encapsulated semiconductors, conservatively rated f or maximum reliability. load regulation (see table for typical variation at different loads) line regulation = typical values 5-15v dc = 1.5% 8-24v dc = 1.5% 18-36v dc = 1.0% unit low high plre 5v 15v plrf 8v 24v plra 18v 36v plrb 36v 60v plrc 18v 60v page 1 of 7 pico electronics: series plr dc - dc converters - lowest profile series 0.300" 12/18/2007 http://www.picoelectronics.com/dcdclow/pe84_85.htm? partno=plr5.2s
per mil. std. 883 expanded operating temp. (-55o c to +85o c) stabilization bake (125o c ambient) temperature cycle (-55o c to +125o c) hi temp, full power burn in (100% power, 125o c cas e temp) 36-60v dc = 1.0% 18-60v dc = 1.5% high efficiency - up to 80% will operate over a temperature range of -25o c to +70o c with no heat sink or electrical derating 6 sided shielding isolation - 100 megohms at 500 volts dc external output trimming pin standard, +5% single and dual isolated outputs each unit is supplied with an external control pin. this "c" pin, when connected to the negative (-) input, will disable t he unit, allowing for remote shutdown. series plr - single output pico part number input volt. range output volt. dc max. load current (ma) max. output power (watts) eff. @ full load typical (%)* input current full load typical (ma)* output volt. ripple@ full ld. 1-1 mhz bw mv p-p output volt. tolerance ( %)* ** v ld. reg. 25% -100% load ( %)* line regu- lation ( %)* price plre3.3s plre5s plr5.2s plre9s plre12s plre15s plre24s plre28s plre48s plre100s 5-15 5-15 5-15 5-15 5-15 5-15 5-15 5-15 5-15 5-15 3.3 5 5.2 9 12 15 24 28 48 100 909 600 577 444 333 267 167 143 83 40 3 3 3 4 4 4 4 4 4 4 75 78 78 78 79 79 80 80 80 80 400 385 385 515 505 505 500 500 500 500 200 175 175 125 125 125 125 125 300 300 1.00 0.75 0.75 0.50 0.50 0.50 0.50 0.50 0.50 0.50 3.00 1.75 1.75 1.50 1.25 1.25 1.00 1.00 1.00 1.00 2.75 2.00 2.00 1.50 1.25 1.25 1.25 1.00 1.00 1.00 188.91 188.91 188.91 188.91 188.91 188.91 188.91 188.91 188.91 236.14 plrf3.3s plrf5s plrf5.2s plrf9s plrf12s plrf15s plrf24s plrf28s plrf48s 8-24 8-24 8-24 8-24 8-24 8-24 8-24 8-24 8-24 3.3 5 5.2 9 12 15 24 28 48 1212 1000 961 556 417 333 208 179 104 4 5 5 5 5 5 5 5 5 75 78 78 78 79 79 80 80 80 333 400 400 400 395 395 390 390 390 200 150 150 125 125 125 125 125 250 1.00 0.75 0.75 0.50 0.50 0.50 0.50 0.50 0.50 3.00 1.75 1.75 1.50 1.25 1.25 1.00 1.00 1.00 2.75 2.00 2.00 1.50 1.25 1.25 1.25 1.00 1.00 188.91 188.91 188.91 188.91 188.91 188.91 188.91 188.91 188.91 page 2 of 7 pico electronics: series plr dc - dc converters - lowest profile series 0.300" 12/18/2007 http://www.picoelectronics.com/dcdclow/pe84_85.htm? partno=plr5.2s
plrf100s 8-24 100 50 5 80 390 300 0.50 1.00 1.00 236.14 plra3.3s plra5s plra5.2s plra9s plra12s plra15s plra24s plra28s plra48s plra100s 18-36 18-36 18-36 18-36 18-36 18-36 18-36 18-36 18-36 18-36 3.3 5 5.2 9 12 15 24 28 48 100 1212 1000 961 556 417 333 208 179 104 50 4 5 5 5 5 5 5 5 5 5 76 76 76 76 77 79 80 80 80 80 195 245 245 245 240 235 230 230 230 230 150 100 100 100 100 100 100 100 250 300 1.00 0.75 0.75 0.50 0.50 0.50 0.50 0.50 0.50 0.50 3.00 2.00 2.00 2.00 2.00 1.50 1.50 1.50 1.00 1.00 1.50 1.00 1.00 0.50 0.50 0.50 0.50 0.50 0.50 1.00 188.91 188.91 188.91 188.91 188.91 188.91 188.91 188.91 188.91 236.14 plrb3.3s plrb5s plrb5.2s plrb9s plrb12s plrb15s plrb24s plrb28s plrb48s plrb100s 36-60 36-60 36-60 36-60 36-60 36-60 36-60 36-60 36-60 36-60 3.3 5 5.2 9 12 15 24 28 48 100 1212 1000 961 556 417 333 208 179 104 50 4 5 5 5 5 5 5 5 5 5 74 74 74 74 74 76 76 76 76 76 113 140 140 140 140 135 135 135 135 135 150 100 100 100 100 100 100 100 200 300 1.00 0.75 0.75 0.50 0.50 0.50 0.50 0.50 0.50 0.50 3.00 1.75 1.75 1.50 1.00 1.00 0.75 0.75 0.75 1.00 1.50 0.50 0.50 0.50 0.25 0.25 0.25 0.25 0.25 1.00 223.26 223.26 223.26 223.26 223.26 223.26 223.26 223.26 223.26 279.07 plrc3.3s plrc5s plrc5.2s plrc9s plrc12s plrc15s plrc24s plrc28s plrc48s plrc100s 18-60 18-60 18-60 18-60 18-60 18-60 18-60 18-60 18-60 18-60 3.3 5 5.2 9 12 15 24 28 48 100 1212 1000 961 556 417 333 208 179 104 50 4 5 5 5 5 5 5 5 5 5 74 75 75 75 75 77 78 78 78 78 139 170 170 170 170 165 165 165 165 165 150 100 100 100 100 100 100 100 225 300 1.00 0.75 0.75 0.50 0.50 0.50 0.50 0.50 0.50 0.50 3.00 2.00 2.00 1.50 1.00 1.00 0.75 0.75 0.75 1.00 1.75 1.50 1.50 1.00 0.75 0.75 0.75 0.75 0.75 1.00 240.43 240.43 240.43 240.43 240.43 240.43 240.43 240.43 240.43 300.54 * measurements taken with input voltage set at mid value. **10% minimum load required. series plr - single output page 3 of 7 pico electronics: series plr dc - dc converters - lowest profile series 0.300" 12/18/2007 http://www.picoelectronics.com/dcdclow/pe84_85.htm? partno=plr5.2s
typical weight: 40 grams larger size drawing larger size schematic series plr - dual output pico part number input volt. range output volt. dc per output max. load current (ma) per output max. output power (watts) per output eff. @ full load typical (%)* input current full load typical (ma)* output volt. ripple@ full ld. 1-1 mhz bw mv p-p output volt. tolerance ( %)* ** v ld. reg. 25% -100% load ( %)* line regu- lation ( %)* price plre5d plre9d plre12d plre15d plre24d plre28d plre48d 5-15 5-15 5-15 5-15 5-15 5-15 5-15 5 9 12 15 24 28 48 300 222 167 134 84 72 42 1.5 2.0 2.0 2.0 2.0 2.0 2.0 78 78 79 79 80 80 80 385 515 505 505 500 500 500 175 125 125 125 125 125 300 0.75 0.50 0.50 0.50 0.50 0.50 0.50 1.75 1.50 1.25 1.25 1.00 1.00 1.00 2.00 1.50 1.25 1.25 1.25 1.00 1.00 231.85 231.85 231.85 231.85 231.85 231.85 231.85 plrf5d plrf9d plrf12d plrf15d 8-24 8-24 8-24 8-24 5 9 12 15 500 278 208 167 2.5 2.5 2.5 2.5 78 78 79 79 400 400 395 395 100 125 125 125 0.75 0.50 0.50 0.50 1.75 1.50 1.25 1.25 2.00 1.50 1.25 1.25 231.85 231.85 231.85 231.85 page 4 of 7 pico electronics: series plr dc - dc converters - lowest profile series 0.300" 12/18/2007 http://www.picoelectronics.com/dcdclow/pe84_85.htm? partno=plr5.2s
plrf24d plrf28d plrf48d 8-24 8-24 8-24 24 28 48 104 89 52 2.5 2.5 2.5 80 80 80 390 390 390 125 125 250 0.50 0.50 0.50 1.00 1.00 1.00 1.25 1.00 1.00 231.85 231.85 231.85 plra5d plra9d plra12d plra15d plra24d plra28d plra48d 18-36 18-36 18-36 18-36 18-36 18-36 18-36 5 9 12 15 24 28 48 500 278 208 167 104 89 52 2.5 2.5 2.5 2.5 2.5 2.5 2.5 76 76 77 79 80 80 80 245 245 240 235 230 230 230 100 100 100 100 100 100 250 0.75 0.50 0.50 0.50 0.50 0.50 0.50 2.00 2.00 2.00 1.50 1.50 1.50 1.00 1.00 0.50 0.50 0.50 0.50 0.50 0.50 231.85 231.85 231.85 231.85 231.85 231.85 231.85 plrb5d plrb9d plrb12d plrb15d plrb24d plrb28d plrb48d 36-60 36-60 36-60 36-60 36-60 36-60 36-60 5 9 12 15 24 28 48 500 278 208 167 104 89 52 2.5 2.5 2.5 2.5 2.5 2.5 2.5 74 74 74 76 76 76 76 140 140 140 135 135 135 135 100 100 100 100 100 100 200 0.75 0.50 0.50 0.50 0.50 0.50 0.50 1.75 1.50 1.00 1.00 0.75 0.75 0.75 0.50 0.50 0.25 0.25 0.25 0.25 0.25 266.19 266.19 266.19 266.19 266.19 266.19 266.19 plrc5d plrc9d plrc12d plrc15d plrc24d plrc28d plrc48d 18-60 18-60 18-60 18-60 18-60 18-60 18-60 5 9 12 15 24 28 48 500 278 208 167 104 89 52 2.5 2.5 2.5 2.5 2.5 2.5 2.5 75 75 75 77 78 78 78 170 170 170 165 165 165 165 100 100 100 100 100 100 225 0.75 0.50 0.50 0.50 0.50 0.50 0.50 2.00 1.50 1.00 1.00 0.75 0.75 0.75 1.50 1.00 0.75 0.75 0.75 0.75 0.75 283.37 283.37 283.37 283.37 283.37 283.37 283.37 * measurements taken with input voltage set at mid value. ** 10% minimum load required. series plr - dual output page 5 of 7 pico electronics: series plr dc - dc converters - lowest profile series 0.300" 12/18/2007 http://www.picoelectronics.com/dcdclow/pe84_85.htm? partno=plr5.2s
for immediate engineering assistance or to place an order: call toll free: 800-431-1064 pico electronics, inc. 143 sparks ave. pelham, ny 10803-1837 tel: 914-738-1400 or fax: 914-738-8225 go back to dc - dc converters menu typical weight: 40 grams larger size drawing larger size schematic ordering instructions: no minimum. net 30 days f.o.b. pelham, ny delivery--stock to one week for sample orders. page 6 of 7 pico electronics: series plr dc - dc converters - lowest profile series 0.300" 12/18/2007 http://www.picoelectronics.com/dcdclow/pe84_85.htm? partno=plr5.2s
page 7 of 7 pico electronics: series plr dc - dc converters - lowest profile series 0.300" 12/18/2007 http://www.picoelectronics.com/dcdclow/pe84_85.htm? partno=plr5.2s
|
