eic corp. a subsidiary of eic enterprises, ltd. www.eiccorp.com 45738 northport loop west, fremont, ca 94538 ? phone: (510) 979-8999 ? fax: (510) 979-8902 1 ss-000249-000 rev g preliminary data sheet EC-1119 high linearity broadband amplifier dc - 6 ghz description the EC-1119 is a high reliability, low cost broadband amplifier, optimized for commercial communications. the device is manufactured using in-house developed, advanced indium gallium phosphide heterojunction bipolar transistor (ingap hbt) technology and is designed for use as a 50 ohm gain block. the amplifier features excellent vswr, low noise figure and highly linear performance. typical oip3 is +36dbm at 80 ma. the EC-1119 operates from a single voltage supply and requires only two dc-blocking capacitors, a bias resistor and an inductor for operation. the device is ideal for wireless applications and is available in a low cost, surface-mountable plastic 85 mil micro-x package. electrical specifications features ? dc to 6 ghz ? 14.8 db gain at 1000 mhz ? 18.6 dbm output p1db at 1000 mhz ? 36 dbm output ip3 at 1000 mhz test conditions: ic = 80 ma, ta = 25 o c applications ? broadband gain blocks ? high linearity amplifiers caution! sensitive electronic device min. typ. max. f frequency dc 6000 mhz f = 1000mhz 14.8 f = 2000mhz 13.5 f = 3000mhz 12.8 f = 2000mhz 13.2 f = 3000mhz 12.2 f = 1000mhz 18.6 p 1db f = 2000mhz 18.6 f = 3000mhz 18.3 f = 1000mhz 19.8 f = 2000mhz 19.9 f = 3000mhz 19.5 f = 1000mhz 35.9 f = 2000mhz 33.2 f = 3000mhz 32.0 rl in input return loss, 50 ohm f = 2000mhz 20.0 db rl out output return loss, 50 ohm f = 2000mhz 24.0 db nf noise figure f = 2000mhz 5.5 db vde device voltage 4.8 v symbol oip3 note 1 saturated output power output third order intercept dbm dbm output power @ 1db compression g g db gain (small signal) db gain (large signal) p in = +5.5 dbm test condition limits unit dbm note 1: oip3 = pout (by power meter, total 2-tone power) + (im3(db))/2) - 3db p sat parameter
ss-000249-000 rev g 2 eic corp. a subsidiary of eic enterprises, ltd. www.eiccorp.com 45738 northport loop west, fremont, ca 94538 ? phone: (510) 979-8999 ? fax: (510) 979-8902 EC-1119 high linearity broadband amplifier preliminary data sheet dc - 6 ghz pin definitions package outline (all units are in inches) absolute maximum ratings note: exceeding any of the absolute maximum ratings may cause permanent damage to the device. .004 to .008? .021 to .031? .052 to .068? .075 to .095? .094 to .106? .017 to .023? .086 to .098? .014 to .026? 1 2 3 4 130 ma 12 dbm operating temperature -40 to +85 c -65 to +150 c junction temperature +200 c device current rf power input storage temperature pin # pin definition 1rfin this pin has a nominal 50 ohm input impedance. it requires a dc blocking capacitor large enough to handle the lowest frequency used. 2, 4 gnd the two ground connections should be directly connected together to the ground plane on the pcb. 3 rfout this pin has a nominal 50 ohm output impedance. it requires a dc bias of 80ma through a series inductor and a resistor. a bypass capacitor (1.0 micro farad) on the dc side of the inductor is recommended for providing instantaneous current during a modulated rf signal. use a dc blocking capacitor on the output with similar requirements as the input side.
eic corp. a subsidiary of eic enterprises, ltd. www.eiccorp.com 45738 northport loop west, fremont, ca 94538 ? phone: (510) 979-8999 ? fax: (510) 979-8902 3 ss-000249-000 rev g preliminary data sheet EC-1119 high linearity broadband amplifier dc - 6 ghz please follow the link on website page ?http://eiccorp.com/products/gain.htm? for detailed s-parameter to 6.1 ghz. typical s-parameters: vde=4.8v, icc=80ma, temperature=25c frequency (mhz) s11 (mag) s11 (ang) s21 (mag) s21 (ang) s12 (mag) s12 (ang) s22 (mag) s22 (ang) 100 0.0081 64.62 5.892 176.4 0.1169 -1.142 0.0570 -6.991 250 0.0207 70.428 5.846 170.79 0.1164 -1.039 0.0573 -16.103 500 0.0406 68.562 5.769 161.605 0.1168 -2.124 0.0577 -32.054 1000 0.0709 59.616 5.562 144.367 0.1167 -3.928 0.0595 -61.318 1500 0.0926 49.117 5.268 127.577 0.1171 -5.683 0.0601 -88.717 2000 0.1029 39.537 5.003 112.23 0.1186 -7.459 0.0612 -117.062 2500 0.1051 31.399 4.679 97.347 0.1188 -9.677 0.0624 -146.841 3000 0.1009 25.504 4.366 83.804 0.1200 -11.365 0.0732 -175.799 3500 0.0911 22.857 4.102 70.348 0.1215 -13.982 0.0939 159.19 4000 0.0824 23.55 3.874 57.65 0.1233 -16.563 0.1223 142.118 4500 0.0740 29.546 3.641 44.83 0.1253 -19.733 0.1586 129.141 5000 0.0704 43.439 3.463 32.675 0.1272 -23.035 0.1996 119.639 5500 0.0850 58.605 3.279 20.029 0.1288 -26.884 0.2407 110.956 6000 0.1094 68.677 3.086 7.797 0.1301 -30.807 0.2865 103.133 reliability and burn-in test eic performs burn-in for selected lots on a regular basis to monitor and guarantee consistent product quality and reliabil- ity. the burn-in process consists of pre-conditioning (jesd22-a113-b), pre and post rf tests, and bias life (jesd22- a108-a). the table is based on the following parameters and conditions: activation energy: 1.85ev junction to ambient temperature difference: + 45 o c confidence levels of 60% and 90% are used to calculate fit (failure in time), for the nominal operating ambient tem- perature at +40 o c. eic will update the burn-in and cumulative fit results periodically. please check the website at www .eiccorp.com test temp hours completed quantity tested quantity failed +145c 1000 80 2 +145c400400 +125c 1000 20 0 22 4.5e+07 hours 43 2.34e+07 hours cumulative fit @ 60% confidence level cumulative mttf @ 60% confidence level (fit 11) cumulative fit @ 90% confidence level cumulative mttf @ 90% confidence level (fit 28)
ss-000249-000 rev g 4 eic corp. a subsidiary of eic enterprises, ltd. www.eiccorp.com 45738 northport loop west, fremont, ca 94538 ? phone: (510) 979-8999 ? fax: (510) 979-8902 EC-1119 high linearity broadband amplifier preliminary data sheet dc - 6 ghz evaluation board schematic recommended bias resistor values r = (vcc-vde)/icc = (vcc-4.8)/0.080 ? ? evaluation board layout evaluation board materials supply voltage (v ) 6 7 8 9 10 11 r1 (ohms) 15 30 43 56 68 82 manufacturer part number qty. description value designators maru ce103k1nr 2 capacitor (0603) 100 pf c1, c2 panasonic ecj-1vf1a105z 1 capacitor (0603) 1.0 uf c3 rohm various 1 resistor (0805) depends on v cc (see table) r1 digi-key tks2386ct-nd 1 inductor (0603) 100 nh l1 ef johnson 142-0701-881 2 sma connector - j1,j2 eic corp ec-1019 1 amplifier - u1 --- 60-000009-003b 1 printed circuit board - ---
eic corp. a subsidiary of eic enterprises, ltd. www.eiccorp.com 45738 northport loop west, fremont, ca 94538 ? phone: (510) 979-8999 ? fax: (510) 979-8902 5 ss-000249-000 rev g preliminary data sheet EC-1119 high linearity broadband amplifier dc - 6 ghz icc vs. vcc 0 40 80 120 160 200 0123456 vcc (v) icc (ma ) 25c 85c -40c p1db vs. frequency 12 16 20 24 0 500 1000 1500 2000 2500 3000 frequency (mhz) p1db (dbm ) 25c 85c -40c figure 1 figure 2
ss-000249-000 rev g 6 eic corp. a subsidiary of eic enterprises, ltd. www.eiccorp.com 45738 northport loop west, fremont, ca 94538 ? phone: (510) 979-8999 ? fax: (510) 979-8902 EC-1119 high linearity broadband amplifier preliminary data sheet dc - 6 ghz figure 3 figure 4 gain vs. frequency, t=25 o c 0 5 10 15 20 01234567 frequency (ghz) s21 (db) s11, s22 vs. frequency, t=25 o c -45 -35 -25 -15 -5 01234567 frequency (ghz) s11, s22 (db) s22 s11
eic corp. a subsidiary of eic enterprises, ltd. www.eiccorp.com 45738 northport loop west, fremont, ca 94538 ? phone: (510) 979-8999 ? fax: (510) 979-8902 7 ss-000249-000 rev g preliminary data sheet EC-1119 high linearity broadband amplifier dc - 6 ghz figure 5 figure 6 reverse isolation vs frequency, t=25 o c -20 -15 -10 -5 0 01234567 frequency (ghz) s12 (db) noise figure vs. frequency, t=25 o c 0 4 8 12 0 500 1000 1500 2000 2500 frequency (mhz) nf (db)
ss-000249-000 rev g 8 eic corp. a subsidiary of eic enterprises, ltd. www.eiccorp.com 45738 northport loop west, fremont, ca 94538 ? phone: (510) 979-8999 ? fax: (510) 979-8902 EC-1119 high linearity broadband amplifier preliminary data sheet dc - 6 ghz oip3 vs. frequency 20 25 30 35 40 0 500 1000 1500 2000 2500 3000 frequency (mhz) output ip3 (db m 25c 85c -40c figure 7
eic corp. a subsidiary of eic enterprises, ltd. www.eiccorp.com 45738 northport loop west, fremont, ca 94538 ? phone: (510) 979-8999 ? fax: (510) 979-8902 9 ss-000249-000 rev g preliminary data sheet EC-1119 high linearity broadband amplifier dc - 6 ghz please visit our website at www .eiccorp.com to view or download the following documents. you may also call our customer service to request a hardcopy. application notes document # description ap-000192-000 discussion of technology and reliability enhancements ap-000194-000 biasing and performance enhancements ap-000487-000 t ape and reel specifications and package drawings ap-000515-000 v oltage spike suppression ap-000516-000 application note index
|
